In the present work the bubble dynamics and heat transfer associated with lateral bubble merger during transition from partial to fully developed nucleate boiling is studied numerically. Complete Navier–Stokes equation in three dimensions along with the continuity and energy equations are solved using the SIMPLE method. The liquid vapor interface is captured using the Level-Set technique. Calculations are carried out for multiple bubble mergers in a line and also in a plane and the bubble dynamics and wall heat transfer are compared to that for a single bubble. The results show that merger of multiple bubbles significantly increases the overall wall heat transfer. This enhanced wall heat transfer is caused by trapping of liquid layer between the bubble bases during merger and by drawing of cooler liquid towards the wall during contraction after merger. Good agreement with data from experiments is found in bubble growth rate and bubble shapes obtained from numerical simulations.

Issue Section:
Research Paper
Keywords:
bubbles, boiling, heat transfer, two-phase flow, Navier-Stokes equations, flow simulation
Topics:
Bubbles, Vapors, Heat transfer
1.
Gaertner
,
R. F.
,
1965
, “
Photographic Study of Nucleate Pool Boiling on a Horizontal Surface
,”
ASME J. Heat Transfer
,
87
, pp.
17
–
29
.
2.
Mikic
,
B. B.
, and
Rohsenow
,
W. M.
,
1969
, “
A New Correlation of Pool-Boiling Data Including the Effect of Heating Surface Characteristics
,”
ASME J. Heat Transfer
,
9
, pp.
245
–
250
.
3.
Yu
,
C. L.
, and
Mesler
,
R. B.
,
1977
, “
A Study of Nucleate Boiling Near the Peak Heat Flux Through Measurement of Transient Surface Temperature
,”
Int. J. Heat Mass Transfer
,
20
, pp.
827
–
840
.
4.
Dhir
,
V. K.
,
1991
, “
Nucleate and Transition Boiling Heat Transfer Under Pool and External Flow Conditions
,”
Int. J. Heat Fluid Flow
,
21
, pp.
290
–
314
.
5.
Ramanujapu, N., and Dhir, V. K., 2000, “On the Formation of Vapor Columns and Mushroom Type Bubbles During Nucleate Boiling on a Horizontal Surface,” in Proceedings of NHTC’00, NHTC2000-12208, Pittsburgh, Pennsylvania.
6.
Chen
,
Tailian
, and
Chung
,
J. N.
,
2002
, “
Coalescence of Bubbles in Nucleate Boiling on Microheaters
,”
Int. J. Heat Mass Transfer
,
45
, pp.
2329
–
2341
.
7.
Chen
,
Tailian
, and
Chung
,
J. N.
,
2003
, “
Heat Transfer Effects of Coalescence of Bubbles From Various Site Distributions
,”
Proc. R. Soc. London, Ser. A
,
459
, pp.
2497
–
2527
.
8.
Son
,
G.
,
Dhir
,
V. K.
, and
Ramanujapu
,
N.
,
1999
, “
Dynamics and Heat Transfer Associated With a Single Bubble During Nucleate Boiling on a Horizontal Surface
,”
ASME J. Heat Transfer
,
121
, pp.
623
–
631
.
9.
Patankar, S. V., 1980, Numerical Heat Transfer and Fluid Flow, Hemisphere Publishing Company, Washington, D.C.
10.
Van Doormaal
,
J. P.
, and
Raithby
,
G. D.
,
1984
, “
Enhancements of the SIMPLE Method for Predicting Incompressible Fluid Flows
,”
Numer. Heat Transfer
,
7
, pp.
147
–
163
.
11.
Patankar
,
S. V.
,
1981
, “
A Calculation Procedure for Two-Dimensional Elliptic Situations
,”
Numer. Heat Transfer
,
4
, pp.
409
–
425
.
12.
Sussman
,
M.
,
Smereka
,
P.
, and
Osher
,
S.
,
1994
, “
A Level Set Approach for Computing Solutions to Incompressible Two-Phase Flow
,”
J. Comput. Phys.
,
114
, pp.
146
–
159
.
13.
Fedkiw, R. P., Aslam, T., Merriman, B., and Osher, S., 1998, “A Nonoscillatory Eulerian Approach to Interfaces in Multimaterial Flows (The Ghost Fluid Method),” UCLA CAM Report No. 98-17, Los Angeles, CA.
14.
Son
,
G.
,
Ramanujapu
,
N.
, and
Dhir
,
V. K.
,
2002
, “
Numerical Simulation of Bubble Merger Process on a Single Nucleation Site During Nucleate Pool Boiling
,”
ASME J. Heat Transfer
,
124
, pp.
51
–
62
.
15.
Kays, W. M., and Crawford, M. E., 1980, Convective Heat and Mass Transfer, McGraw–Hill, New York, p. 328.
Copyright © 2004
 by ASME
You do not currently have access to this content.