Surface-tension forces can drive fluid motion within thin liquid layers with a free surface. Spatial variations in the temperature of the free surface create surface tractions that drive cellular motions. The cells are most commonly hexagonal in shape and they scale on the thickness of the fluid layer. This investigation documents the formation of cells in the liquid film in the presence of a uniform-heat-flux lower boundary condition. Liquid crystal thermography was used to image the cells and measure the temperature distribution on the lower surface of the liquid layer. A 1.1 mm deep pool of silicone oil was supported on a $50 μm$ thick electrically heated metal foil. The oil was retained inside an independently heated acrylic ring mounted on the top surface of the foil and a dry-ice cooling plate served as the low-temperature sink above the free surface of the oil. Color images of hexagonal convection cells were captured using liquid crystal thermography and a digital image acquisition and processing system. The temperature distribution inside a typical cell was measured using thermographic image analysis. Experimental issues, such as the use of an independently heated retaining ring to control the height of the liquid film and the utility of a flux-based Marangoni number are discussed.

1.
Bénard
,
H.
, 1900, “
Les tourbillons cellulaires dans une nappe liquid
,”
Rev. Gen. Sci. Pures Appl.
0370-5196,
11
, pp.
1261
1271
.
2.
Block
,
M. J.
, 1956, “
Surface Tension as the Cause of Bénard Cells and Surface Deformation
,”
Nature (London)
0028-0836,
178
, pp.
650
651
.
3.
Pearson
,
J. R. A.
, 1958, “
On Convection Cells Induced by Surface Tension
,”
J. Fluid Mech.
0022-1120,
4
, pp.
489
500
.
4.
Koschmieder
,
E. L.
, and
Biggerstaff
,
M. I.
, 1986, “
Onset of Surface-Tension-Driven Benard Convection
,”
J. Fluid Mech.
0022-1120,
167
, pp.
49
64
.
5.
Koschmieder
,
E. L.
, and
Prahl
,
S. A.
, 1990, “
Surface-Tension-Driven Benard Convection in Small Containers
,”
J. Fluid Mech.
0022-1120,
215
, pp.
571
583
.
6.
Ostrach
,
S.
, and
Kamotani
,
Y.
, 1995, “
Surface Tension Driven Convection Experiment
,” NASA Lewis Research Center Pamphlet No. B-0806.
7.
Hay
,
J. L.
, and
Hollingsworth
,
D. K.
, 1996, “
A Comparison of Trichromic Systems for Use in the Calibration of Polymer-Dispersed Thermochromic Liquid Crystals
,”
Exp. Therm. Fluid Sci.
0894-1777,
12
, pp.
1
12
.
8.
Hay
,
J. L.
, and
Hollingsworth
,
D. K.
, 1998, “
Calibration of Micro-encapsulated Liquid Crystals Using Hue Angle and a Dimensionless Temperature
,”
Exp. Therm. Fluid Sci.
0894-1777,
18
, pp.
251
257
.
9.
Bayazit
,
B. B.
,
Hollingsworth
,
D. K.
, and
Witte
,
L. C.
, 2003, “
Heat Transfer Enhancement Caused by Sliding Bubbles
,”
ASME J. Heat Transfer
0022-1481,
125
(
3
), pp.
503
509
.
10.
Daniel
,
E.
,
Hollingsworth
,
D. K.
, and
Witte
,
L. C.
, 2007, “
Transition From Boiling Onset to Fully Developed Nucleate Boiling in a Narrow Vertical Channel
,”
Heat Transfer Eng.
0145-7632,
28
(
10
), pp.
885
894
.
11.
Dutton
,
T. W.
, 1996, “
Liquid Crystal Imaging of Surface-Tension-Driven-Convection
,” BS honors thesis, Department of Mechanical Engineering, University of Houston, Houston, TX.
12.
Pate
,
L. R.
, 1999, “
Investigation of Surface-Tension-Driven Flows on a Uniform-Flux Surface
,” MS thesis, Department of Mechanical Engineering, University of Houston, Houston, TX.
13.
Koschmieder
,
E. L.
, 1967, “
On Convection Under an Air Surface
,”
J. Fluid Mech.
0022-1120,
30
, pp.
9
15
.
14.
Kline
,
S. J.
, and
McClintock
,
F. A.
, 1953, “
Describing Uncertainties in Single Sample Experiments
,”
Mech. Eng.
,
75
, pp.
3
8
.
15.
Baughn
,
J. W.
,
Anderson
,
M. R.
,
Mayhew
,
J. E.
, and
Wolf
,
J. D.
, 1999, “
Hysteresis and Uncertainty of Thermochromic Liquid Crystal Temperature Measurement Based on Hue
,” ASME-JSME Paper No. AJTE99/6294.